din rail timer Waterheatertimer.org
is a self-help site
How to install and troubleshoot garbage disposal repair disposal
Type 1 and type 2 surge protection surge protection
How to install recirculation system Point of use water heater
Auto-off timers Programmable wall timers Compare 16 electric and 2 gas water heater timers
How to install point of use water heater Point of use water heater
Search waterheatertimer.org / all results
Search using Find button  

 Tweet button  
How to wire DT 1440 timer
How to wire TB17 TB178 TB118 timers
TB 178 timer manual
DTD 1400 timer
Larger image
DT 1440 timer
220 Volt AC
15 Amp x 220 Volts = 3300 watts
Motor load 220Volt 1500 watt= max 1/3 Hp motor
Select 50 or 60 Hz to match local power worldwide
Wires identical to TB178 timer

Override knob located upper right corner.
Timer resumes regular schedule at next tripper
To override permanently, remove trippers
How to set timers

Install trippers on dial. 30 minute on-off minimum.
Manually rotate dial two times to see how load turns on-off.
Set trippers at selected on-off times
Rotate dial until current time lines up with white arrowhead located on inner dial.
Timer dial rotates as time passes. Tripper pushes on-off lever.
If dial does not rotate, then check incoming voltage, replace timer with new timer.
TB 178 timer

DTD-1400 Timer

TB178 Timer

TB118 Timer

Input 100-240Volt AC
Mim 88 volts AC Max 264 volts AC
50-60 Hz for worldwide application

How to wire TB 178 timer For heavy duty switching, connect timer to contactor.
Over 1/3 Hp, install contactor
Add busman fuses to lines between power source and timer.
Fuse will protect timer from overload and possible fire hazard.
Select contactor with coil voltage to match line voltage

Wire and breaker chart

How to wire 240Volt outlets and plugs

Legrand  649-915 4QT timer

20 amp
50-60 cycle means timer works worldwide electric grid

Identical wiring shown above
How to set analog timers

Small segements located around dial
Move a few segments, and then rotate dial to watch how lights turn on-off
Set switch to ON for timer to operate on schedule
Set current time: rotate dial until correct time shows on clock face, or until current time lines up with pointer marked current time.

More timers and manuals
SUL 18 timer
Larger image

SUL 18 timer

Use contactor to control heavy-amp loads
Protect timer with 15 amp fuse

Wire and breaker chart

How to wire 240Volt outlets and plugs
Intermatic FM1 timer
Wiring shows load connected to NO terminal, or Normally Open
Terminal 4 is NC > or Normally Closed > this terminal has power when terminal 5 is OFF
When terminal 5 is ON, then terminal 4 is OFF
Intermatic FM1 timer
Quartz models rated 50-60 Hz
Different model numbers for 24V, 120V, 240V
Dry terminals mean other voltages can be controlled
Newest FM1 sell sheet
How to wire under counter water heater using FM1
24 Hour with 15 minute intervals
7-day with 2 hour intervals
Override offers permanent ON, or permanent OFF

FM1 override switch
GM40 timer dial

How to wire FM1 timer FM1 timer dial
Rotate dial until current time shows on clock face
Intermatic FM1 timer    Intermatic MIL series
FM1                      MIL series
Deihl 880
Intermatic PB 800 series      Intermatic PB 800 series
PB series             PB series How to wire DT 1440 timer
How to wire TB17 TB178 TB118 timers
TB 178 timer manual
Intermatic PB300  Intermatic FM1D20
PB300 series                FM1D series
Intermatic FM1D20
FM2D 2-channel series
CN101A timer wiring 
Amico                      Digi 14 series
Intermatic DIGI timer     Diehl 884 timer
FM1 digi                   Other models
Add solder when attaching terminals to solid copper wire.
Put solder iron point where wire terminates. Wait until hot. Keep solder iron in place. Touch solder to copper wire. Solder melts. Withdraw solder. Withdraw solder iron.
How to make terminal connections
Yellow terminals for 12 gauge wire; Blue terminals for 14 gauge wire
Talento 111 timer wiring

Talento 111 timer wiring

More din rail timers with similar wiring
Talento 111 mini 211 mini manual
Talento 111, 121, 171, 211, 271, 212, 202
How to set analog timers

Intermatic Talento timers
Onesto Fato and Misc

How to wire Din Rail timers
ST01C timer controls 240Volt water heater
Timer has green ground wire
Ground wire not shown.

ST01C digital timer controls any voltage

Digital timer
Battery operated CR2 battery
Single-pole or 3-way

Intermatic ST01c timer at Amazon
Intermatic ST01 timer
Ei600 5-year warranty timer at Amazon
CR2 replacement battery at Amazon
CFL bulbs at Amazon

50-60 Hz
24 volt AC, 12 volt DC
Load ratings for Intermatic timers/ pdf
Wire ST01C timer

More uses for ST01 timer

ST01 timer controls water heater or any 240 volt load
Resource: Control motor with ST01 timer

Reverse ST01 using Intermatic air switch   /
: Intermatic air switches

Use ST01C for 4-way timer

ST01 24 volt DC photoeye

Convert single-pole switch into 3-way switch using ST01/
 Resource: How to add a switch   How to add 3-way switch

ST01 timer controls HVAC

How to wire Tork DTU40
How to wire Intermatic GM40
Intermatic GM series
Intermatic EH10 and WH21
Intermatic EH40 and WH40
Intermatic T-101 T103 T104
Pool timers and manuals
Intermatic T104P201

GE box timers
Wire GE 15207 timer
Intermatic ET series
Intermatic ET104C
Pool timers and manuals
Tork pool timers and manuals
Intermatic T104P201
Gas and electric water heaters Support the economy:
Buy water heaters  from my associate links:

50 gallon Gas water heaters at Amazon
40 gallon gas water heaters at Amazon
50 gallon Electric water heaters at Amazon
40 gallon electric water heaters at Amazon
Hybrid / heat pump/ water heaters at Amazon

How to install gas water heater
How to install electric water heater
Troubleshoot gas water heater
Troubleshoot electric water heater
Point of use water heaters
Gas and electric water heaters Industrial electric at Amazon

Industrial supplies at Amazon

Industrial and scientific Amazon
Shop Amazon - DEWALT
Shop Amazon - Black and Decker
Shop Amazon - Stanley Tools
Shop Amazon - SKIL Tools
Shop Amazon - Porter-Cable Tools
Shop Amazon - Bosch Tools
Shop Amazon saws and saw blades
box timers Compare box timers

Control water heater w/ Z-wave
Intermatic control centers Control centers:
+ manuals and parts

All control centers and parts

Including Z-wave
programmable timer Compare programmable timers

Control water heater with programmable wall timer
Countdown timers Compare countdown timers

Control water heater with countdown timer
Low voltage power packs Low voltage transformers

Type 1 and type 2 surge protection surge protection
E-mail: geno03245w@gmail.com
My response might end up in spam folder, check email folders
Site map
Follow newest idea on twitter
Privacy policy