Wire to Old Work Box

Waterheatertimer.org is a self-help site	Compare 16 electric and 2 gas water heater timers	Try a water heater timer free	Figure Volts Amps Watts for water heater	9 ways to save with water heater	Troubleshoot electric water heater	Do-it-yourself

2011

Install Wire to Old Work Box:

Drop wire from attic into old work box

Larger image

Instructions: Cut 2-1/4" x 3-3/4" hole in sheetrock using knife or saw > find electric wire inside wall > pull electric wire through hole > feed wire into box > set box into hole > turn screws so pop-up fin tightens against inside of sheetrock > install switch.

Note: Water Heater Timer requires only one box and one wire.
old work box

Larger image

14-2 romex

Larger image

I use GE 15070 timer to control water heater
All timers with same features
Eye-level installation: easy to change times, set override, reset current time after power outage and seasonal time-change, and turn water heater ON-and-OFF manually to override timer function.
30-minute timer intervals: Summertime 15-30 minutes for shower, wintertimer 30-45 minutes for shower.
Image shows timer mounted on wall below attic light switch. Timer is same size as typical light switch

See timer installation

How to drop wire into wall covered with sheetrock

View from inside attic

Step 1) Locate wall from inside attic

1.Before going in attic, choose wall for switch

2. Avoid walls with pocket door or plumbing pipes or exterior walls with insulation

3. Go in attic and estimate location of wall

4. Pull back insulation & find top plate as shown

5. Measure exact location or have helper tap on wall from below

Cut-away view of interior wall

Step 2) Drill hole and drop wire into wall

If another wire already drops through top plate where you want your wire, see if your wire will push through same hole. If you have to drill, move over several inches from existing hole so drill won't contact wires.

When drilling through top plate 3 things may occur:
1.) You may hit a nail > drill another hole
2.) You may hit top of upright 2x4 > drill another hole
3.) You may drill into the wrong cavity > that's why you drill through top plate before cutting hole in sheetrock

Tip: after drilling hole in top plate - and - before cutting hole in sheetrock, drop your wire into wall and have helper rattle it around to make sure you're in the right spot. Put timer at eye-level so it's easy to program.

How to Install box support

Grainger

Back to Page 2: Connect wires

Additional links

Troubleshoot Household electricity

How to twist wire
How to wire Cooper 277
How to wire combo switch-outlet
How to replace 3-speed fan switch

How to wire 3-way switches
How to wire 4-way switches
How to wire TM811 and TM8111 switches
How to wire wall timers
How to wire box timers

How to wire photo eyes
How to wire photo eyes

Troubleshoot Malibu outdoor lights
Terminals
Select and install wire nuts
Select wire size

Replace breaker
Install subpanel

Electrical formulas
Electricians forum

How to wire GFCI
How to wire GFCI combo

Basic water heater circuit
How to wire water heater for 120Volt
Install old work box

How to drop wire from attic
Romex connector

How to wire 240volt outlets
How to install 3-phase timer
How to wire 3-phase outlets

See inside main breaker box
Fuseholder
Contactors
How to solder wires
Whole house surge protector
3-phase surge protection
Circuit breakers

Difference between 120 volt and 240 Volt
How to install electric meter on water heater
How to wire water heater thermostat
How to wire water heater with switches and timers

6x6x4 Enclosures

Electricity from pole to breaker box	Compare box timers	Contactors	Do it yourself water heater
240 V Intermatic water heater timer	Compare all water heater timers

Water heater Box timers

Intermatic trippers and parts	Dayton	Sprinkler timers	Power pack
Wire T1906 and T1905 timers	Wire T-101 T103 T104 timers	Paragon timers and manuals	Westek box timers
Wire EH40 and WH40 timers	Tork timers and manuals	Troubleshoot intermatic	Sylvania timers
How to set analog timers	Pool timers and manuals	Wire GE 15207 timer	Intermatic GM series
3-phase timer	GE box timers	Gardena timers	Westinghouse timers Timex timers Brinks timers

E-mail: info@waterheatertimer.org
Site map